LoginRegister
SnowandMud.com - Powered by vBulletin

Today's Posts
Page 1 of 2 12 LastLast
Results 1 to 10 of 11

07 summit 800 engine problems

Discuss 07 summit 800 engine problems in the SNOWMOBILE RELATED DISCUSSIONS AND RIDING AREA's forums; hello, i was riding yesterday and had a weird issue with my sled. It starts great and runs great most ...


  1. #1
    Member wakeskate18's Avatar
    Join Date
    Nov 2008
    Location
    Kelowna
    Posts
    42
    Post Thanks / Like

    07 summit 800 engine problems

    hello,

    i was riding yesterday and had a weird issue with my sled. It starts great and runs great most of the time, however once we were in some deeper snow and hill climbing for 5 minutes, the sled would have full RPM's and then the RPMS would drop right off and the sled would bog down. I have to let the thorttle all the way off and then I can get good revs again and get moving. It seems to get worse once it starts.

    Any helpful hints or suggestions would be great.

    Thanks!!!



  2. #2
    Member MoFoREVxp154's Avatar
    Join Date
    Mar 2007
    Location
    Edmonton
    Posts
    77
    Post Thanks / Like

    Re: 07 summit 800 engine problems

    The first think to look at is

    ---Is there any sort of oily spots around the carbs-if so then the line to the RAVE solenoid fell off(pointed toward the oil tank) If so then cut the hose off thats protruding past the clamp and re-crimp the clamp with side cutters and reinstall hose(hose might of fell down between the carb/oil tank) DONT WORRY about engine leaning out, there aret check valves so It wont suck air into case.

    Also check to see if the RAVEs are openeing when need be(7000RPM) and are opening at the same time-just pull off the black caps to get a good look at them(RAVEs should be cleaned once a year)

    If thats not it then the spring cup is hanging up probably from sloppy fit on the shaft-Replace the cup AND slide 1/2 bushing at the same time. I also recomend to change the rollers at the same time.

    ALSO MAKE SURE not to have the heated carbs on-will run like a bag when hot.
    Ride'R'hard...Play'M'safe

  3. #3
    Senior Member
    Modman's Avatar
    Join Date
    Mar 2008
    Location
    Calgary
    Posts
    5,174
    Post Thanks / Like

    Re: 07 summit 800 engine problems

    Fuel pump maybe?
    Some people only ever dream of angels - for a moment, I held one in my hand.

    The price of anything is the amount of life you exchange for it. - Henri David Thoreau

  4. #4
    Member
    bayman's Avatar
    Join Date
    Nov 2008
    Location
    Calgary
    Posts
    435
    Post Thanks / Like

    Re: 07 summit 800 engine problems

    Does it go into reverse ok.....sounds like the submarine I bought last year. Checked everything and it turned out to be a spun crank shaft. Hopefully not the case for you.

  5. #5
    Member skibeadoo's Avatar
    Join Date
    Feb 2008
    Location
    Central AB
    Posts
    290
    Post Thanks / Like

    Re: 07 summit 800 engine problems

    I would start with the spring cap as well. I had some weird problems with the relay. It did the same type of stuff. Changed the relay from Napa and changed the spring cap. Problems solved.

    Then I would check Raves and do a compression check to make sure.
    Compression is not high on 07 as it is. It was down from the factory for some reason.
    2007 REV XRS 151
    2009 X XP 163

  6. #6
    Member rustyrocket's Avatar
    Join Date
    Nov 2009
    Location
    Prince George
    Posts
    9
    Post Thanks / Like

    Re: 07 summit 800 engine problems

    Quote Originally Posted by skibeadoo View Post
    I would start with the spring cap as well. I had some weird problems with the relay. It did the same type of stuff. Changed the relay from Napa and changed the spring cap. Problems solved.

    Then I would check Raves and do a compression check to make sure.
    Compression is not high on 07 as it is. It was down from the factory for some reason.
    Check you're compression . That 800 R motor is junk . if the motor is week . don't not rebuild with skidoo pistons .there single ring and expensive . buy the dual ring piston . Bombardier will not have this , you need to buy after market . i bought a kit and gasket kit for 300.00 out of the states , buy now as our dollar is high . And when was the last time you rebuilt your clutch . Keep it clean should have no problems . that's my take .

  7. #7
    Member skibeadoo's Avatar
    Join Date
    Feb 2008
    Location
    Central AB
    Posts
    290
    Post Thanks / Like

    Re: 07 summit 800 engine problems

    Quote Originally Posted by rustyrocket View Post
    Check you're compression . That 800 R motor is junk . if the motor is week . don't not rebuild with skidoo pistons .there single ring and expensive . buy the dual ring piston . Bombardier will not have this , you need to buy after market . i bought a kit and gasket kit for 300.00 out of the states , buy now as our dollar is high . And when was the last time you rebuilt your clutch . Keep it clean should have no problems . that's my take .
    RU stupid or something? Did you not even read his initial post. He never asked anything about the engine being blown. What you got to trash mine or anyones comments. We all know that there was many problems. I have had my share. But grow up "newbie".
    2007 REV XRS 151
    2009 X XP 163

  8. #8
    Member
    doohead's Avatar
    Join Date
    Nov 2009
    Location
    Okotoks
    Posts
    379
    Post Thanks / Like

    Re: 07 summit 800 engine problems

    rustyrocket....WTF dude? lol.....some peoples kids....lol....
    Make your own adventure, STAY OUT OF MY TRACK!!!!



  9. #9
    Member
    POWDERSLUT's Avatar
    Join Date
    Feb 2008
    Location
    Da Loops
    Posts
    2,153
    Post Thanks / Like

    Re: 07 summit 800 engine problems

    what condition is your belt in.
    Trashy668
    LMFAO!!!!!! Go rub one out Darcy or have sex with your wife, instead of jacking off to other guy's gf's/wives
    Sumx54
    I don't jack off to other guys wives you douche bag. And I do have sex with my wife on a regular basis. Who are you shaggin trashy ? I mean other than your pets...

  10. #10
    Member Hefe04's Avatar
    Join Date
    Dec 2008
    Location
    Red Deer
    Posts
    161
    Post Thanks / Like

    Re: 07 summit 800 engine problems

    My ran that way one day or close to it and I found that the vac line to the air box on the panel had come off

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  


Search Engine Friendly URLs by vBSEO